Product ID:X-935 MIL-A-91170 ADHESIVE SEALING FOR AROMATIC FUEL
MSDS Date:04/17/1991
FSC:8040
NIIN:00-262-9060
MSDS Number: BWKVQ

BAKER SEALANTS AND COATINGS CO

234 SUYDAM AVE
JERSEY CITY, NJ 07304-3306
US

Emergency Phone: 201-333-6986

Info Phone: 201-333-6986

Preparer: CHARLES FRIEDHAM

Cage: 34094

STEVEN INDUSTRIES

8 BAYONNE, NJ 07002-3417 US

Telephone: 201-437-6501

Cage: 33150

2-BUTANONE (METHYL ETHYL KETONE) (MEK)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 66%

OSHA PEL 200 PPM

ACGIH TLV: 590 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

TETRAHYDROFURAN

CAS: 109-99-9

RTECS: LU5950000

Fraction By Weight: 7%

OSHA PEL 200 PPM

ACGIH TLV: 590 MG/CUM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

VINYL RESIN

CAS: 25086-48-0

Fraction By Weight: 23%

CARBON, ACTIVATED CARBON, GRAPHITE

CAS: 7440-44-0

RTECS: FF5250100

Fraction By Weight: 1-5%

OSHA PEL 10 MG/CUM

ACGIH TLV: 10 MG/CUM

NATURAL, RUBBER SOLUTION (DOT)

CAS: 9006-04-6

RTECS: VL8020000

Fraction By Weight: 1-3%

Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITATION & POSSIBLE
PERMANENT DAMAGE. SKIN: IRRITATION & DERMATITIS. INHALATION:
RESPIRATORY TRACT IRRITATION, CNS EFFECTS. INGESTION: SMALL AMOUNTS
OF LIQUID ASPIRATED INTO RESPIRATORY SYSTEM BY INGESTION/VOMITING
MAY CAUSEBRONCHIOPNEUMONIA/PULMONARY EDEMA.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHES, DIZZINESS.

First Aid:EYES: IMMEDIATELY FLUSH W/LARGE AMOUNTS OF WATER FOR 15 MINS.
SKIN: IMMEDIATELY FLUSH W/LARGE AMOUNTS OF WATER, USE SOAP IF
AVAILABLE. INHALATION: IMMEDIATELY REMOVE TO FRESH AIR. GIVE CPR IF
NEEDED. INGESTION: DON'T INDUCE VOMITING. ASPIRATION HAZARD. KEEP
AT REST. OBTAIN MEDICAL ATTENTION IN ALL CASES.

Flash Point:23F
Lower Limits:2
Upper Limits:10
Extinguishing Media:ALCOHOL FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS W/FULL
FACE PIECE OPERATED IN POSITIVE PRESSURE DEMAND MODE.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR, MAY TRAVEL
ALONG GROUND/MOVED BY VENTILATION TO DISTANT IGNITION SOURCES.

Spill Release Procedures:LARGE: REMOVE IGNITION SOURCES. EVACUATE AREA.
STOP AT SOURCE. DIKE/PREVENT SPREADING/PUMP LIQUID TO SALVAGE
TANKS. TAKE UP RESIDUE W/SAND/CLAY/EARTH/FLOOR ABSORBENT/OTHER
ABSORBENT MATERIAL & SHOVEL INTO CONTAINERS. (SEE SUPP)

Other Precautions:CONTAINERS MAY BE HAZARDOUS WHEN EMPTIED. CONTAINERS
RETAIN PRODUCT RESIDUES. NEVER USE WELDING/CUTTING TORCH NEAR
DRUM/EMPTY CONTAINER, CAN IGNITE.

Respiratory Protection:WEAR A NIOSH/MSHA APPROVED AIR SUPPLIED
RESPIRATOR IF WORKPLACE EXPOSURE LIMITS OF PRODUCT/ANY COMPONENT IS
EXCEEDED/IN ABSENCE OF PROPER ENVIRONMENTAL CONTROL.
Ventilation:MECHANICAL (GENERAL &/LOCAL EXHAUST) SUFFICIENT TO MAINTAIN
EXPOSURE BELOW TLV.
Protective Gloves:NATURAL RUBBER/NEOPRENE
Eye Protection:CHEMICAL SPLASH GOGGLES
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE.
Supplemental Safety and Health
SPILLS CONT'D: SMALL: ABSORB LIQUID ON PAPER/VERMICULITE/FLOOR
ABSORBENT/OTHER ABSORBENT MATERIAL & TRANSFER TO CONTAINERS. WASTE
DISPOSAL CONT'D: LARGE: DESTROY BY LIQUID INCINERATION.
CONTAMINATED A BSORBENT MAY BE DEPOSITED IN LANDFILL IAW/FEDERAL,
STATE, COUNTY & LOCAL REGULATIONS. FLAMMABLE LIQUID UN1133

HCC:F2
Boiling Pt:B.P. Text:175F
Melt/Freeze Pt:M.P/F.P Text:<32F
Vapor Pres:70
Vapor Density:2.5
Spec Gravity:0.81
pH:6.8
Evaporation Rate & Reference:(BU AC = 1): 6
Solubility in Water:APPRECIABLE
Appearance and Odor:CHARACTERISTIC
Percent Volatiles by Volume:70-80

Stability Indicator/Materials to Avoid:YES
CAUSTICS, AMINES, ALKANOLAMINES, AMMONIA, STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:PILOT LIGHTS, FLAMES, SPARKS, HEATERS,
SMOKING, ELECTRIC MOTORS, STATIC DISCHARGE & OTHER IGNITION
SOURCES.
Hazardous Decomposition Products:CO, CO2 & VARIOUS ORGANIC BY-PRODUCTS.

Waste Disposal Methods:SMALL: ALLOW VOLATILE PORTION TO EVAPORATE &
ALLOW SUFFICIENT TIME FOR VAPORS TO COMPLETELY CLEAR. DISPOSE OF
IAW/FEDERAL, STATE, COUNTY & LOCAL REGULATIONS. (SEE SUPP)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.